新闻动态 
所在位置: 首页>>新闻动态
四平盛元换热设备——带你了解换热器使用与维护

一、换热器的日常维护

Daily maintenance of heat exchangers

日常操作应特别注意防止温度、压力的波动,首先应保证压力稳定,不允许超压运行。

Daily operation should pay special attention to prevent temperature and pressure fluctuations, first of all should ensure that the pressure is stable, and must not allow overpressure operation.

二、换热器的清洗

Heat exchanger cleaning

换热设备经长时间运转后,由于介质的腐蚀、冲蚀、积垢、结焦等原因,使管子内外表面都有不同程度的结垢,甚至堵塞。所以在停工检修时须进行清洗,常用的清洗(扫)方法有风扫、水洗、汽扫、化学洗清和机械清洗等。

After the heat transfer equipment is operated for a long period of time, due to the corrosion, erosion, scaling, and coking of the medium, the internal and external surfaces of the pipes have different degrees of scaling and even blockage. Therefore, thorough cleaning must be carried out during downtime maintenance. The commonly used cleaning(cleaning) methods include wind cleaning, water washing, Steam cleaning, chemical cleaning, and mechanical cleaning.


但这种传统的清洗方式如机械方法(刮、刷)、高压水、化学清洗(酸洗)等在对设备清洗时出现很多问题:不能清除水垢等沉积物,酸液对设备造成腐蚀形成漏洞,残留的酸对材质产生二次腐蚀或垢下腐蚀,导致更换设备,此外,清洗废液有毒,需要大量资金进行废水处理。

However, this traditional cleaning method, such as mechanical methods(scraping, brushing), high-pressure water, chemical cleaning(pickling), etc., has many problems in cleaning the equipment: it is not possible to completely remove sediments such as scale, and the acid solution causes corrosion to the equipment. Forming loopholes, The residual acid causes secondary corrosion of the material or corrosion under scale, which eventually leads to the replacement of the equipment. In addition, the cleaning waste solution is toxic and requires a large amount of funds for wastewater treatment.

但采用环保、无腐蚀,可生物降解的福世泰克环保清洗剂,不但清洗效果良好而且对设备没有腐蚀,能够保证凝汽器的长期使用。

However, the use of highly efficient, environmentally friendly, safe, non-corrosive, biodegradable Forsytek environmental protection cleaning agent, not only good cleaning effect and no corrosion to the equipment, can ensure the long-term use of condenser.

福世泰克清洗剂(添加湿润剂和穿透剂,可以有效清除用水设备中所产生的顽固的水垢(碳酸钙)、锈垢、油垢、粘泥等沉淀物,同时不会对人体造成伤害,不会对钢铁、紫铜、镍、钛、橡胶、塑料、纤维、玻璃、陶瓷等材质产生侵蚀、点蚀、氧化等其他有害的反应,可大大延长设备的使用寿命。

Fushitaike cleaning agent(unique added moisturisers and penetrators, can effectively remove the most stubborn scale(calcium carbonate), Rust, tartar, slime and other sediments produced in water equipment, while not causing harm to the human body, It will not cause erosion, point erosion, oxidation and other harmful reactions to steel, copper, nickel, titanium, rubber, plastic, fiber, glass, ceramics and other materials, which can greatly extend the service life of the equipment.

同时清洗液是可生物降解的(获得美国环保局认可批准),完全可以直接排放,在排放前不需进行中和处理。

Simultaneous cleaning fluids are biodegradable(approved by the U.S. Environmental Protection Agency) and can be discharged directly without neutralization before discharge.


版权声明:本文转载自网络,版权属原作者。部分文章推送时未能与原作者取得联系,若涉及版权问题,烦请原作者联系我们,我们会在即时处理,谢谢!


四平盛元换热设备有限公司 电话:18504440666 13904347890 地址:四平市铁西区北沟街北新华大街98号